2003–2006 Ford Expedition Fuse Box Diagram

Passenger compartment fuse panel / power distribution box

The fuse panel is located under the right-hand side of the instrument panel.
2003–2006 Ford Expedition Fuse Box Diagram
To remove the trim panel for access to the fuse box, pull the panel toward you and swing it out away from the side and remove it. To reinstall it, line up the tabs with the grooves on the panel, then push it shut.
2003–2006 Ford Expedition Fuse Box Diagram
To remove the fuse box cover, place a finger behind the PULL tab and your thumb above the PULL tab as shown in the illustration, then pull the cover off.
To reinstall the fuse box cover, place the top part of the cover on the fuse panel, then push the bottom part of the cover until you hear it click shut. Gently pull on the cover to make sure it is seated properly.
2003–2006 Ford Expedition Fuse Box Diagram



A
Description
1
7.5
Run/Accessory - Front wiper motor,
Instrument cluster,
Rear wiper motor
2
20 Turn signal/Hazard flasher,
Stoplamp switch,
Stoplamps,
Center high-mount stop light (CHMSL),
Turn signal lamps
3
7.5 Power mirror switch,
Power mirrors (non-memory),
Driver seat switch (memory),
Memory module (logic power)
4
15
DVD player,
Rear seat audio controls,
CDDJ (navigation radio)
5
7.5
Powertrain Control Module (PCM) (KA power),
Speed control deactivation switch,
Manual climate control mode switch,
Stoplamp switch,
Brake-shift interlock (BSI) solenoid,
EATC control head,
Body Security Module (BSM) (KA power),
3rd row seat relay coils,
SecuriLock LED
6
15 Headlamp switch (parklamps and switch backlight feed),
Parklamps,
License plate lamps,
Foglamp relay coil,
Trailer tow electric brake controller (illumination),
BSM (autolamp, parklamps) Foglamp indicator
7
5
Radio (start signal)
8
10
Rear window defroster switch,
Rear window defroster indicator (climate control head),
Heated outside mirrors
9
-
Not used
10
20
Trailer tow back-up lamps relay,
Trailer tow 7–wire connector (back-up lamps),
Trailer tow parklamp relay,
Trailer tow 7– and 4–pin connectors (parklamps)
11
10
A/C compressor clutch relay,
A/C compressor clutch solenoid,
4x4 Integrated Wheel Ends (IWE) solenoid
12
15
Fuel pump relay,
Fuel pump shut-off switch,
Fuel pump driver module,
Fuel pump motor
13
10
Manual climate control mode switch,
Rear window defroster relay coil,
A/C refrigerant containment switch,
A/C de-icing switch,
A/C low pressure switch,
DATC control head,
DATC solenoids,
DATC blower control,
Trailer tow battery charge relay coil
14
10
Daytime Running Lamps (DRL) ignition relay coil,
Digital Transmission Range Sensor (DTRS) back-up lamps,
Trailer tow back-up lamps relay coil,
Electrochromatic mirror,
Manual A/C blend door actuator
15
5
AdvanceTrac® with RSC switch, Instrument cluster (Run/Start feed)
16
10
BS/AdvanceTrac® with RSC module (Run/Start feed)
17
15
Foglamps
18
10
Auxiliary A/C temperature blend door actuator,
Auxiliary A/C front auxiliary control,
Turn signal flasher,
Electrochromatic mirror,
Auxiliary mode motor
19
10
Restraints Control Module (RCM)
20
30
BSM (door locks, liftgate glass release relay),
Liftgate glass release motor,
Door/Liftgate lock motors
21
15
Instrument cluster (B+),
Interior (courtesy) lamps,
Puddle lamps (outside mirrors)
22
10
Moonroof switch illumination,
Radio (delayed accessory feed),
Flip window switch,
Flip window motors,
EHAM antenna amplifier (navigation radio)
23
10
RH low beam
24
15
Interior demand lamps (front map/dome lamp, 2nd row dome/map lamp, glove compartment lamp, cargo lamp, roof rail lamps, vanity mirror lamps),
Battery saver relay coil,
Battery saver relay power,
Heated Positive Crankcase Ventilation (PCV) valve
25
10
LH low beam
26
20
Horn relay,
Horns
27
5
Compass module,
Reverse sensing system module,
Brake shift interlock solenoid,
Overdrive cancel switch,
Air suspension module (Run/Start sense)
28
5
PCM relay coil,
SecuriLock transceiver,
Heated PCV valve relay coil
29
30
Trailer tow electric brake controller,
Trailer tow 7–wire connector (electric brake)
30
25
Air suspension module (air spring solenoids and height sensors),
PCM (4x4 transfer case clutch)
31
20
Radio (B+),
Subwoofer
32
15
Catalyst Monitor Sensors (CMS),
Transmission solenoids,
Canister vent solenoid,
HEGO sensors,
VMV solenoid,
A/C compressor clutch relay coil,
CMCV,
VCT actuators
33
-
Not used
34
15
PCM,
Fuel injectors,
Mass Air Flow (MAF) sensor
35
20
Instrument cluster high beam indicator,
High beam headlamps
36
10
Trailer tow right turn/stop lamps
37
20
Cargo area power point
38
25
Rear wiper motor,
Washer pump (rear window wash)
39
20
Console power points (front and rear of console),
Instrument panel power point (bench seat)
40
20
DRL relays, DRL foglamps,
DRL headlamp relay coil,
Headlamp switch (headlamps),
Multifunction switch (flash-to-pass),
BSM (autolamp headlamps relay),
High beam relay coil,
Fuse 25 (LH low beam),
Fuse 23 (RH low beam)
41
20
Cigarette lighter,
OBD II diagnostic connector
42
10
Trailer tow left turn/stop lamps
101
30
Starter motor relay,
Starter motor solenoid
102
30
Ignition switch power
103
30
ABS/AdvanceTrac® with RSC module (pump motor)
104
30
LH 3rd row seat relay,
LH 3rd row seat switch,
LH 3rd row seat motor
105
30
Spare
106
30
Trailer tow battery charge relay,
Trailer tow 7–way connector (battery charge)
107
30
Auxiliary A/C blower relay,
Auxiliary A/C blower motor
108
30
Passenger seat motor switch
109
30
Driver seat motor switch (non-memory),
Memory module,
Power memory mirrors,
Adjustable pedals switch and motor
110
30
Spare
111
50
Air suspension compressor,
Air suspension compressor relay
112
30
ABS/AdvanceTrac® with RSC module (valves)
113
30
Front wiper motor,
Washer pump (windshield wash)
114
40
Rear window defroster relay,
Rear window defroster grid,
Heated mirrors (Fuse 8)
115
30
Transfer case shift motor,
4x4 relays
116
40
Front blower motor relay,
Front blower motor
117
30
RH 3rd row seat relay,
RH 3rd row seat switch,
RH 3rd row seat motor
118
30
Driver and passenger climate control seat module
401
30
Power windows (circuit breaker),
Main window switch,
Window motors,
Window switches,
Moonroof module
R01

Starter relay:
Starter motor solenoid
R02

Delayed accessory relay:
Fuse 22,
CB 401,
Power windows,
Switch backlighting,
Radio,
Moonroof,
Flip windows,
Navigation antenna amplifier
R03

Hi-beam relay:
Fuse # 35,
Hi-beam headlamps,
Hi-beam indicator
R04

Rear window defrost relay:
Fuse 8 (heated mirrors),
Rear window defroster,
Heated outside mirrors,
Rear window defroster indicator (climate control head)
R05

Trailer tow battery charge relay:
Trailer tow 7–wire connector (battery charge)
R06

Front blower relay:
Front blower motor
R201

Trailer tow park lamp relay:
Trailer tow 7–wire and 4–wire connectors (park lamps)
R202

Foglamp relay:
Front foglamps
R203

PCM relay:      
Fuse 32,
Fuse 34,
PCM solenoids and sensors
R301

Trailer tow back-up lamp relay:
Trailer tow 7–wire connector (back-up lamps)
R302

Heated PCV valve relay:
Heated PCV valve
R303

Fuel pump relay:
Fuel pump shut-off switch,
PCM (fuel pump monitor),
Fuel pump,
Fuel pump driver module
R304

Battery saver relay:
Roof rail lamps,
Vanity mirror lamps,
Map/Dome lamp,
Glove box lamp,
Cargo area lamp,
Outside mirror puddle lamps, Instrument cluster (interior lamps)
R305

Horn relay:
Dual note horn
Fuse Box Diagram Ford Expedition (U222; 2003, 2004, 2005, 2006)