2006-2009 Ford LCF (Low Cab Forward)
Fuse Box
The Power distribution box is located behind the cab on the right-hand frame rail, behind a protective cover.
To access the Power distribution box, the protective cover must be taken off the vehicle by removing the two screws, then gently pulling the cover off.
Once the cover has been removed, simply lift the tab on the Power distribution box cover to access the fuses and relays.
| No. | A | Description |
|---|---|---|
| 1 | — | Not used |
| 2 | 30 | Starter |
| 3 | 20 | Park lamps |
| 4 | 50 | 2008-2009: Injector Driver Module (IDM)/Powertrain Control Module (PCM) |
| 40 | 2006-2007: Injector Driver Module (IDM)/Powertrain Control Module (PCM) | |
| 5 | 30 | Headlamps |
| 6 | 40 | Blower motor |
| 7 | 25 | Wipers |
| 8 | 30 | Electric brakes |
| 9 | 20 | Door locks |
| 10 | 20 | Stoplamps |
| 11 | 20 | Fuel pump |
| 12 | 20 | RUN/ACC feed |
| 13 | 20 | RUN/START feed |
| 14 | 15 | Horn |
| 15 | 10 | Cluster |
| 16 | 15 | Back-up lamps |
| 17 | 15 | Fog lamps |
| 18 | 15 | Transmission |
| 19 | 20 | Fuel heater |
| 20 | 60 | Anti-lock Brake System (ABS) module |
| 21 | 20 | Trailer lighting circuit |
| 22 | 30 | 2006-2007: Body builder circuits |
| 23 | 40 | Trailer battery charge |
| 24 | 20 | Cigar lighter |
| 25 | 20 | Hazard flasher |
| 26 | 15 | Remote Keyless Entry (RKE) |
| 27 | 10 | Radio |
| 28 | 10 | Dome lamp |
| 29 | 60 | ABS pump |
| 30 | 30 | HVAC pusher fan |
| 31 | 20 | Diagnostic connector |
| 32 | 40 | Power windows |
| 33 | 25 | Body builder prep |
| 34 | 20 | A/C clutch |
| 35 | 20 | Cluster |
| 36 | — | Not used |
| 37 | 10 | Turn signals |
| 38 | — | Not used |
| 39 | 10 | Cornering lamps |
| 40 | 10 | IDM logic power, Fan drive |
| 41 | 10 | PCM power |
| 42 | 10 | Radio |
| 43 | — | Not used |
| 44 | — | Not used |
| 45 | — | Not used |
| 46 | 20 | 2008-2009: PCM key power |
| 5 | 2006-2007: PCM key power | |
| Relay | ||
| 47 | Body builder prep | |
| 48 | Fuel pump | |
| 49 | Back-up lamps | |
| 50 | 2006-2007: PCM | |
| 51 | Fuel heater | |
| 52 | Transmission | |
| 53 | A/C clutch | |
| 54 | Fog lamps | |
| 55 | 2008-2009: ECM 2006-2007: IDM |
|
| 56 | Wiper | |
| 57 | Starter | |
| 58 | Not used | |
| 59 | Park lamps | |
| 60 | Transmission relay diode | |
| 61 | Not used | |
Relay Box
The relay box is located under the center of the instrument panel.
The instrument panel lower trim panel must be removed to access the relays. Remove the plastic rivet from the driver side of the trim panel.
Remove the two screws on the passenger side bottom of the panel, then the plastic rivets on the top end. Push the panel up slightly to disengage the locking tabs, then pull the panel toward you and off.
2006
| No. | Description |
|---|---|
| R1 | Low beams |
| R2 | High beams |
| R3 | Blower motor |
| R4 | Power windows |
2007-2009
| No. | Description |
|---|---|
| A/C DEMAND | Climate control |
| HORN | Horn |
| RT FRONT | Right front turn signal |
| TURN SIGNAL | Turn signals |
| IGN. | Ignition |
| PUSHER FAN | HVAC pusher fan |
| LEFT FRONT | Left front turn signal |
| DOME LAMP | 2008-2009: Dome lamp |
| RT REAR | Right rear turn signal |
| HEADLAMP | Headlamps |
| BLOWER MOTOR | Climate control blower motor |
| LEFT REAR | Left rear turn signal |
| HIGH/LOW | Headlamp high/low beams |
| POWER WINDOWS | Power windows |
