2001-2009 Volvo S60 and S60 R Fuse Box Diagram

Volvo S60
2001–2009
2011-present
2001-2009 Volvo S60 and S60 R Fuse Box Diagram
2011-2018 Volvo S60 and S60 Cross Country Fuse Box Diagram

Location

2001-2009 Volvo S60 and S60 R Fuse Box Diagram
  1. Engine compartment fuse box (2001-2005) / (2006-2009)
  2. Fuse box in the passenger compartment within the sound barrier on the driver’s side (2005-2009)
  3. Fuse box in the passenger compartment at dashboard end on driver’s side
  4. Fuse box in cargo compartment (2001-2004) / (2005-2009)

Engine compartment fuse box (2001-2005)

2001-2009 Volvo S60 and S60 R Fuse Box Diagram



No. Protected Circuit A
1 Parking heater (option) 25
2 Auxiliary lamps (option) 20
3 2005: Throttle (5-cyl without turbo/Bi-fuel) 10
4 Petrol: Oxygen sensors
2004-2005; Diesel: Engine Control Module (ECM), high-pressure valve
20
5 2001-2002: Crankcase ventilation heater, solenoid valves
15
2003-2005: Crankcase ventilation heater, Solenoid valves
2004-2005; Bi-Fuel: Fuel distributor
10
6 Petrol: Mass an flow sensor, engine control modulo, injectors
15
Diesel: Mass air flow sensor 10
7 2001-2004: Throttle control
10
8 Accelerator pedal sensor (APM), A/C compressor, fan electronics box (2003-2005)
10
9 2001-2004: Horn 15
2005; Bi-fuel LPG: Gas tank valve
10
10 - -
11 2001-2004: A/C compressor, Ignition coils, Electric fan (2001-2002), Solenoid valves (2004; diesel)
2005: Ignition coils, relay coils
20
12 2001-2004: Brake light contact
5
13 Windscreen wipers 25
14 ABS / STC (203-2004) / DSTC (2001-2004)
30
15 2004; Bi-Fuel: Gas tank valve (Bi-Fuel
15
2005: High-pressure washer, headlamps
35
16 2001-2004: Windshield wipers, headlight washers
15
17 2002-2004: Dipped beam (right)
10
2005: Dipped beam (right)
20
18 2002-2004: Dipped beam (right) 10
2005: Parking lamps (front)
15
19 ABS / STC (203-2004) / DSTC (2001-2004)
30
20 2002-2004: Main beam (left) 15
2005: Dipped beam (right)
20
21 2002-2004: Main beam (right)
15
2005: Fuel pump
15
22 2001-2003: Starter motor 25
2004: Starter motor
40
2005: Starter motor
35
23 2001-2004: Engine Control Module (ECM)
5
2005: Engine Control Module (ECM) supply, engine relay (ECR) coil
10
24 Not used
-

Engine compartment fuse box (2006-2009)

2001-2009 Volvo S60 and S60 R Fuse Box Diagram



Protected Circuit A
1 ABS 30
2 ABS 30
3 High-pressure washer, headlamps 35
4 Parking heater 25
5 Auxiliary lamps 20
6 Starter motor relay 35
7 Windscreen wipers 25
8 2006-2007: Transmission control module (TCM), diesel, R-models 15
2008-2009: Fuel pump
15
9 2006-2007: Fuel pump 15
2008-2009: Transmission control module (TCM), diesel
15
10 Ignition coils (petrol), engine control module (ECM), injection valves (diesel) 20
11 Accelerator pedal sensor (APM), AC compressor, fan electronics box 10
12 Petrol: Engine control module (ECM), injection valves, mass air flow sensor
15
Diesel: Mass air flow sensor
5
13 Petrol: Electronic throttle module (ETM) 10
Diesel: Electronic throttle module (ETM), air mixing valve, fuel pressure regulator, solenoid valve 15
14 Petrol: Lambda-sond 20
Diesel: Lambda-sond 10
15 Petrol: Crankcase ventilation heater, solenoid valves
10
Diesel: Solenoid valves, glow plugs
15
16 Dipped beam, left 20
17 Dipped beam, right 20
18 - -
19 Engine control module (ECM) supply, engine relay 5
20 Position lamps 15
21 2009: Vacuum pump 20

Fuses in the passenger compartment

2001-2009 Volvo S60 and S60 R Fuse Box Diagram



No. Protected Circuit A
1 2001-2002: Left low beam
10
2003-2004: Headlamps (dipped beam), Bi-Xenon (option)
15
2005-2009: Power driver’s seat
25
2 2001-2002: Right low beam 10
2003-2004: Headlamps (main beam)
20
2005-2009: Power passenger seat
25
3 2001-2002: Headlights, low beams 15
2003-2004: Power driver's seat
2005-2009: Climate control system fan
30
4 2001-2002: Headlights, high beams 20
2003-2004: Power passenger seat
30
2005-2009: Control module, right front door
25
5 2001-2002: Power driver's seat 30
2003-2004: Speed-dependent power steering, vacuum pump
15
2005-2009: Control module, left front door
25
6 2001-2002: Power passenger seat 30
2004; Bi-Fuel: Gas tank valve
5
2005-2009: General lighting, ceiling (RCM), Upper Electronic Module (UEM)
10
7 2001-2004: Heated seat (front left)
2005-2009: Sunroof
15
8 2001-2004: Heated seat (front right) 15
2005-2009: Ignition switch, SRS system, Engine Control Module (ECM), SRS deactivation passenger side (PACOS), immobiliser (IMMO), Transmission control module (TCM; Diesel and R-models - from 2006)
7,5
9 2001-2004: ABS / STC (2003-2004) / DSTC (2003-2004)
2005-2009: OBDII, light switch (LSM), Steering Angle Sensor (SAS), Steering Wheel Module (SWM)
5
10 2001-2002: Left high beam
15
2005-2009: Audio
20
11 2001-2002: Right high beam
15
2005-2009: Amplifier
30
12 2001-2004: Headlamp levelling (2004), headlamp wipers 15
2005-2009: RTI display
10
13 2001-2002: Electric socket 12V 20
2003-2004: Electric socket 12V
15
2005-2009: Telephone
5
14-38 - 2005-2009: Not used
14 Power seat passenger side, Front seat belt buckle (2001-2002)
5
15 2001-2003: Audio, VNS
2004: Audio RTI (option)
5
16 Audio 20
17 Amplifier 30
18 2001-2002: Front fog lights 5
2003-2004: Front fog lights
15
19 2001-2003: VNS
2004: RTI-display (option)
10
20 2002: Transport switch
5
21 Automatic transmission, shiftlock, extended D2 feed 10
22 Direction indicators 20
23 Light switch module, Switch module (2001-2002), Climate and comfort functions, Diagnostic connector, Steering wheel module
5
24 2001-2002: Relay increase X- feed: Climate control, Power driver's seat, Driver info
2003-2004: Extended Dl-feed, climate control system, power seat (driver), combined instrument panel, parking heater (option)
10
25 2001-2002: Ignition switch 30 feed: Central electronic module: 50, S, X, 15 Airbag X, Relay X, Relay 15, Relay Starter motor
2003: Ignition switch, relay starter motor, SRS, engine control module
2004: Ignition switch (30-feed), Central Electronic Module, relay starter motor, engine control module
10
26 Climate control system blower 30
27 2001-2002: Electronic module - front doors and door mirrors
2004: Active chassis FOUR-C
15
28 Electronic module (roof), interior lighting (ceiling) 10
29 Telephone
10
30 2001-2002: Position/parking lamps (left - front and rear) 10
2003-2004: Position/parking lamps (left - front and rear)
7,5
31 2001-2002: Position/parking lamps (right - front and rear), numberplate lighting 10
2003-2004: Position/parking lamps (right - front and rear), numberplate lighting
7,5
32 Central electrical module, vanity mirror lighting, power steering, glove compartment light (2003-2004), interior courtesy lighting (2003)
10
33 Fuel pump 15
34 Sunroof 15
35 Central locking system, power windows. left door mirror 25
36 Central locking system, power windows. right door mirror 25
37 Rear power windows, power child safety locks (2003-2004)
30
38 2003-2004: Alarm siren 5

Fuses in the passenger compartment within the sound barrier on the driver’s side (2005-2009)

2001-2009 Volvo S60 and S60 R Fuse Box Diagram



No. Protected Circuit A
1 Seat heating, right side 15
2 Seat heating, left side 15
3 Horn 15
4 - -
5 - -
6 Reserve -
7 Reserve -
8 Siren 5
9 Brake lamp switch feed 5
10 Combined instrument panel (DIM), climate control (CCM) parking heater, power driver's seat 10
11 Front and rear seat socket 15
12 - -
13 Reserve -
14 S60 R, 2005-2006: Headlamp wipers
15
15 ABS, STC/DSTC 5
16 Bi-fuel, Electronically Controlled Power Steering (ECPS), Bi-Xenon, headlamp levelling 10
17 Fog lamp, front left 7,5
18 Fog lamp, front right 7,5
19 Reserve -
20 Reserve -
21 Transmission Control Module (TCM), reverse gear inhibitor (M66) 10
22 Main beam, left 10
23 Main beam, right 10
24 - -
25 - -
26 Reserve -
27 Reserve -
28 Power passenger seat, audio 5
29 2008-2009: BiFuel, fuel pump 7,5
30 BLIS 5
31 Reserve -
32 Reserve -
33 Vacuum pump 20
34 S60 R, 2005-2006: Washer pump, headlamp wipers
15
35 - -
36 - -

Fuses in the cargo compartment (2001-2004)

2001-2009 Volvo S60 and S60 R Fuse Box Diagram



No. Protected Circuit A
1 Rear electronic module, Cargo compartment lighting 10
2 Rear fog lamps 10
3 Brake light 15
4 Backup lights 10
5 Rear window defroster, Relay 15I (accessories) 5
6 Tailgate opening 10
7 Folding head restraints 10
8 Central locking rear doors, Fuel filler door 15
9 Trailer hitch (30 feed) (accessory) 15
10 CD changer, CD ROM (2001-2002), VNA (2001-2002), Antenna (2001-2002), VNS (2003), RTI (2004) 10
11 Accessory control module (AEM) 15
12 - -
13 - -
14 2003-2004: Brake light 7,5
15 Trailer hitch (15 I feed) 20
16 Electric socket, cargo compartment (option) 15
17 Diesel, 2004: Heated fuel filter
AWD cars, 2002-2004:Control module, all-wheel drive
7,5
18 Diesel, 2004: Heated fuel filter
15

Fuses in the cargo compartment (2005-2009)

2001-2009 Volvo S60 and S60 R Fuse Box Diagram



No. Protected Circuit A
1 Reversing lamp 10
2 2005-2007: Parking lamps, fog lamps, cargo compartment lighting, number plate lighting, LEDs in brake lighting 15
2008-2009: Position lamps, fog lamps, cargo area lighting, number plate lighting, lamps in brake lighting
20
3 2005-2007: Accessories (AEM) 20
2008-2009: Accessories (AEM)
15
4 Reserve -
5 REM electronics 10
6 CD changer, TV, RTI 7,5
7 Towing bracket wiring (30-feed) 15
8 Cargo compartment socket 15
9 Rear right door: power window, power window lock 20
10 Real left door: power window, power window lock 20
11 Reserve -
12 Reserve -
13 Diesel filter heater 15
14 - -
15 Reserve -
16 Reserve -
17 Audio accessories 5
18 Reserve -
19 Foldable head restraint 15
20 Towing bracket wiring (15-feed) 20
21 Reserve -
22 - -
23 AWD 7,5
24 Four-C SUM 15
25 - -
26 Parking assistance 5
27 Main fuse: Towing bracket wiring, Four-C, Parking assistance, AWD 30
28 Central locking system (PCL) 15
29 Trailer lighting, left: parking lamp, direction indicator
25
30 Trailer lighting, right: brake lamp, rear fog lamp, direction indicator 25
31 Main fuse: Fuse 37, 38 40
32 - -
33 - -
34 - -
35 - -
36 - -
37 Heated rear window 20
38 Heated rear window 20
Fuse Box Diagram Volvo S60 and S60 R; engine: 2.0, 2.3, 2.4, 2.5 (2001, 2002, 2003, 2004, 2005, 2006, 2007, 2008, 2009)