2008-2010 Volkswagen Caddy Fuse Box Diagram

27.10.2016 (US:10.27.16), Category: Volkswagen / Caddy

Year of production Volkswagen Caddy (2K):
October 2003 - May 2005
May 2005 - November 2008
November 2008 - 2010
2010-2014

Fitting locations

2008-2010 Volkswagen Caddy Fuse Box Diagram
  1. Fuses on fuse holder A -SA- (On the electronics box, on left in engine compartment)
  2. Fuses on fuse holder B -SB- (On left in engine compartment)
  3. Fuses on fuse holder C -SC- (Under left dash panel)



Fitting location of fuse holder A (A -SA-)

2008-2010 Volkswagen Caddy Fuse Box Diagram
No. A Function/component
1 150
Alternator -C- 90A / 110A
1
200
Alternator -C- 140A
2 80
Power steering control module -J500-
    Electromechanical power steering motor -V187-
3 50
Radiator fan control unit -J293-
    Radiator fan -V7-
    Right fan for coolant -V35-
Radiator fan thermal switch -F18-
    Radiator fan -V7-
4 502)
803)
Onboard supply control unit -J519-2)
X-contact relief relay -J59-2)
    Fuse 7 on fuse holder -SC7-
    Fuse 8 on fuse holder -SC8-
    Fuse 28 on fuse holder -SC28- to -SC33-
5 100 Fuses on fuse holder C -SC-
    Fuse 20 on fuse holder -SC20- to -SC24-  
    Fuse 42 on fuse holder -SC42- to -SC52-
6
40
Low heat output relay -J359-4)
    Auxiliary air heater element -Z35-
7
80
High heat output relay -J360-4)
    Auxiliary air heater element -Z35-
1) Only models with continuously variable radiator fan
2) Only models with central locking
3) Only models without central locking
4) Only models with auxiliary air heater (PTC)

Fitting location of E-box high fuse holder (B -SB-)

2008-2010 Volkswagen Caddy Fuse Box Diagram



No. A Function/component
1 - Not used
2 -
Not used
3 5
Onboard supply control unit -J519-
4 30
ABS Control Module -J104-
5 15
Mechatronics unit for dual clutch gearbox -J743-
6 -
Not used
7 40 Terminal 15 voltage supply relay 2 -J681-
8 15
Control module with display for radio and navigation system -J503-
Radio -R-
9 5
Mobile telephone operating electronics control module -J412-
Not used (from May 2009)
10 10
Motronic current supply relay -J271- (BUD, BSX)
Term. 30 voltage supply relay -J317- (BDJ, BST, BLS, BMM, BSU, BJB)
Engine control module -J623- (BSX, BUD)
11 20
Auxiliary heater control unit -J364-
12 5
Data bus diagnostic interface -J533-
Not used (from May 2009)
13 15
Engine control module -J623- (BSX, BUD)
Simos control module -J361- (BSE, BSF)
13
30
Diesel direct injection system control module -J248- (BDJ, BJB, BLS, BMM, BST, BSU)
14 20
Ignition coil 1 with output stage -N70- (BSX, BUD)
Ignition coil 2 with output stage -N127- (BSX, BUD)
Ignition coil 3 with output stage -N291- (BSX, BUD)
Ignition coil 4 with output stage -N292- (BSX, BUD)
Ignition transformer -N152- (BSE, BSF, BSX)
15 5
Fuel pump relay -J17- (BDJ, BJB, BLS, BMM, BST, BSU)
Glow plug relay -J52- (BDJ, BST)
Automatic glow period control module -J179- (BJB, BLS, BMM, BSU)
15
10
Fuel pump switch-off relay -J333- (BSX)
Cylinder 1 injector -N30- (BUD)
Cylinder 2 injector -N31- (BUD)
Cylinder 3 injector -N32- (BUD)
Cylinder 4 injector -N33- (BUD)
Gas injector 1 -N366- (BSX)
Gas injector 2 -N367- (BSX)
Gas injector 3 -N368- (BSX)
Gas injector 4 -N369- (BSX)
16 30
Onboard supply control unit -J519- , right headlight
17 -
Not used
18 30
Special vehicle control unit -J608-
19 30
Windscreen wiper motor -V-
20 40
Glow plug 3 -Q12- (BDJ, BST)
Glow plug 4 -Q13- (BDJ, BST)
20
10
Tank shut-off valve 1 -N361- (BSX) (from May 2009)
Tank shut-off valve 2 -N362- (BSX) (from May 2009)
Tank shut-off valve 3 -N363- (BSX) (from May 2009)
Tank shut-off valve 4 -N429- (BSX) (from May 2009)
Tank shut-off valve 5 -N430- (BSX) (from May 2009)
21 10
Lambda probe heater -Z19- (BLS, BMM)
21
15
Lambda probe heater -Z19- (BSE, BSF, BSX, BUD)
Lambda probe 1 heater after catalytic converter -Z29- (BSE, BSF, BSX, BUD)
22 5
Clutch position sender -G476-
23 5
Secondary air pump relay -J299- (BSE)
Exhaust gas recirculation valve -N18- (BDJ, BST)
23 10
Exhaust gas recirculation valve -N18- (BJB, BSU)
Charge pressure control solenoid valve -N75- (BJB, BLS, BMM, BSU)
Exhaust gas recirculation cooler changeover valve -N345- (BJB, BLS, BMM, BSU)
Tank shut-off valve 1 -N361- (BSX) (up May 2009)
Tank shut-off valve 2 -N362- (BSX) (up May 2009)
Tank shut-off valve 3 -N363- (BSX) (up May 2009)
High-pressure valve for gas operation -N372- (BSX)
Tank shut-off valve 4 -N429- (BSX) (up May 2009)
24 10
Cylinder 1 injector -N30- (BSX)
Cylinder 2 injector -N31- (BSX)
Cylinder 3 injector -N32- (BSX)
Cylinder 4 injector -N33- (BSX)
Activated charcoal filter solenoid valve 1 -N80- (BSE, BSF, BUD)
Variable intake manifold changeover valve -N156- (BSE, BSF)
Intake manifold flap motor -V157- (BDJ, BST)
Radiator fan control unit -J293-
Protective resistor -N235-
25 40
ABS Control Module -J104-
26 40
Onboard supply control unit -J519- , left headlight
27 40
Secondary air pump relay -J299- ( BSE)
    Secondary air pump motor -V101-
Glow plug 1 -Q10- (BDJ, BST)
Glow plug 2 -Q11- (BDJ, BST)
27
50
Automatic glow period control module -J179- (BJB, BLS, BMM, BSU)
    Glow plug 1 -Q10-
    Glow plug 2 -Q11-
    Glow plug 3 -Q12-
    Glow plug 4 -Q13-
28 -
Not used
29 30
Fuses on fuse holder C -SC- (special-purpose vehicles)
    Fuse 18 on fuse holder -SC18-
    Fuse 19 on fuse holder -SC19-  
    Fuse 35 on fuse holder -SC35- to -SC39- 
    Fuse 57 on fuse holder -SC57-   
    Fuse 58 on fuse holder -SC58-
30
50
Fuses on fuse holder C -SC- (only with trailer coupling) (up May 2009)
    Fuse 39 on fuse holder -SC39- to -SC41-
Fuses on fuse holder C -SC- (only with trailer coupling) (from May 2009)
    Fuse 40 on fuse holder -SC40- to -SC42-

Position of fuses on fuse holder C -SC-

2008-2010 Volkswagen Caddy Fuse Box Diagram



No. A Function/component
1 - Not used
2 - Not used
3 - Not used
4 - Not used
5 - Not used
6 - Not used
7 - Not used
8 - Not used
9 10
4-pin connector -T4g- (applies to special vehicles only)
10-pin connector -T10c- (for models with electric interface only)
10 5
Fuel pump relay -J17- (BSE, BSF, BUD, BSX)
Terminal 15 voltage supply relay -J329- (BSE, BSF)
Data bus diagnostic interface -J533-
Engine control unit -J623-
11 5
Parking aid control unit -J446- (only models with parking aid)
12 5
Taxi meter -G41- (only taxi)
Mirror taxi meter -G511- (only taxi)
12 10
2-pin connector -T2ac- (applies to special vehicles only)
28-pin connector -T28a- (applies to special vehicles only)
13 5
Headlight range control regulator -E102-
Left headlight range control motor -V48-
Right headlight range control motor -V49-
Traction control system switch -E132-
TCS and ESP button -E256-
Selector lever -E313- (only models with direct shift gearbox)
Brake light switch -F-
Brake light relay -J111- (only models without central locking)
ABS control unit -J104-
Trailer detector control unit -J345-
Power steering control unit -J500- (only models with power steering)
Selector lever sensors control unit -J587- (only models with direct shift gearbox)
Mechatronic unit for dual clutch gearbox -J743- (only models with direct shift gearbox)
Four-wheel drive control unit -J492-
14 5
Air mass meter -G70- (BLS, BSU, BJB, BDJ, BST, BMM, CHWA)
Heater element for crankcase breather -N79- (BSE, BSF, BLS, BSU, BJB, BSX, BMM, CHWA)
Reversing light switch -F4-
Auxiliary heater operation relay -J485- (only models with auxiliary coolant heater)
Activated charcoal filter system solenoid valve 1 -N80- (BSX)
16-pin connector -T16- (self-diagnosis connection)
15 5
Airbag control unit -J234-
Front passenger side airbag deactivated warning lamp -K145-
16 5
Heater/heat output switch -E16- (only models without air conditioning system)
High pressure sender -G65- (only models with air conditioning system)
Oil level and oil temperature sender -G266- (only for models with flexible service interval display)
Climatronic control unit -J255- (only models with Climatronic)
Control unit in dash panel insert -J285-
Low heat output relay -J359- (only models with PTC (Positive Temperature Coefficient) heater)
High heat output relay -J360- (only models with PTC (Positive Temperature Coefficient) heater)
Automatic anti-dazzle interior mirror -Y7-
Air quality sensor -G238- (only models with Climatronic)
17 7.5
Left tail light and rear fog light bulb -M41- (models without central locking)
Rear fog light cut-out contact switch -F216- (only models with trailer operation and without central locking)
18 5
Taxi alarm remote control, control unit -J601- (only taxi)
10-pin connector -T10c- (for models with electric interface only)
19 5
10-pin connector -T10c- (for models with electric interface only)
19 10
Taxi meter -G41- (only taxi)
Mirror taxi meter -G511- (only taxi)
Two-way radio -R8- (only taxi)
20 7.5
Onboard supply control unit -J519- (Interior light)
21 10
Selector lever -E313- (only models with direct shift gearbox)
Selector lever sensors control unit -J587- (only models with direct shift gearbox)
Tiptronic switch -F189- (only models with direct shift gearbox)
Automatic gearbox control unit -J217-
16-pin connector -T16- (self-diagnosis connection)
Climatronic control unit -J255- (only models with Climatronic)
Heater/heat output switch -E16-
Air conditioning system control unit -J301-
Remote control receiver for auxiliary coolant heater -R149- (only models with remote control receiver for auxiliary coolant heater)
Light switch -E1-
Rain and light detector sensor -G397- (models with rain and light detector sensor only)
Control unit in dash panel insert -J285-
Steering column electronics control unit -J527-
Data bus diagnostic interface -J533-
22 10
Driver door control unit -J386-
Front passenger door control unit -J387-
23 5
Interior light switch (taxi) -E115- (only taxi)
Taxi sign switch -E138- (only taxi)
Hands-free system button -E487- (only taxi)
23 10
3-pin connector -T3r- (applies to special vehicles only)
10-pin connector -T10c- (for models with electric interface only)
24 5
Interior monitoring sensor -G273-
Vehicle inclination sender -G384-
Alarm horn -H12-
25 -
Not used
26 10
2-pin connector -T2ab- (applies to special vehicles only)
27 15
Cut-out relay for air conditioning system magnetic coupling -J246- (only for models with hydraulic steering)
28 5
Light switch -E1- (models with central locking)
28 20
Rear fog light switch -E18- (only models without central locking)
29 15
Rear window wiper motor -V12- (models with rear window wiper only)
30 25
Light switch -E1- (only models without central locking)
31 5
Heater/heat output switch -E16- (only models without air conditioning system)
Air conditioning system control unit -J301- (only models with air conditioning system)
Climatronic control unit -J255- (only models with air conditioning system)Left washer jet heater element -Z20-
Right washer jet heater element -Z21-
32 15
Windscreen and rear window washer pump -V59-
33 40
Heater/heat output switch -E16-
Air conditioning system control unit -J301-
Auxiliary heater operation relay -J485- (only models with auxiliary coolant heater)
34 -
Not used
35 10
Fluorescent light in rear of high roof -W41- (applies to special vehicles only)
Fluorescent light in centre of high roof -W42- (applies to special vehicles only)
36 - Not used
37 15
Right dipped beam bulb -M31- (models without central locking)
38 15
Left dipped beam bulb -M29- (models without central locking only)
39 20
10-pin connector -T10ai- (applies to special vehicles only)
40 20
Trailer detector control unit -J345-
41 20
Trailer detector control unit -J345-
42 20
Trailer detector control unit -J345-
43 15
Electric fuel pump 2 relay -J49- (BSE, BSF, BUD, BSX)
Fuel pump relay -J17- (BDJ, BST, BLS, BSU, BJB, BSE, BSF, BUD, BSX, BMM)
44 40
Fresh air blower control unit -J126-
45 20
Headlight washer system relay -J39- (only models with headlight washer system)
Headlight washer system pump -V11- (only models with headlight washer system)
46 15
Treble tone horn -H2-
Bass tone horn -H7-
Horn relay -J413-
47 25
Cigarette lighter -U1-
48 30
Heated front seats control unit -J774-
49 30
Driver door control unit -J386- (only for model with electric window regulator)
Front passenger door control unit -J387- (only for model with electric window regulator)
50 25
Convenience system central control unit -J393-
51 30
10-pin connector -T10ai- (applies to special vehicles only)
52 25
Fresh air blower relay -J13- (only models with auxiliary heater)
Onboard supply control unit -J519-
Heated rear window -Z1-
53 15
12 V socket -U5- (near handbrake lever)
53 30
12 V socket -U5- (near handbrake lever)
12 V socket 2 -U18- (left luggage compartment)
54 -
Not used
55 -
Not used
56 -
Not used
57 5
2-way radio switch -E72- (applies to special vehicles only)
Engine continues to run without key button -E489- (applies to special vehicles only)
Accident data memory -J754- (applies to special vehicles only)
10-pin connector -T10c- (for models with electric interface only)
58 10
4-pin connector -T4g- (applies to special vehicles only)
59 - Not used
60 - Not used
Fuse Box Diagram Volkswagen Caddy (2008, 2009, 2010)