2004-2013 Volvo C30, S40, V50, C70
Fuse Box Diagram Volvo S40, C70, C30, C70; Petrol - 1.6L, 1.8L, 2.0L, 2.4L & 2.5L T5 and Diesel - 1.6L, 2.0L & 2.4L (2004, 2005, 2006, 2007, 2008, 2009, 2010, 2011, 2012, 2013)
Passenger Compartment Fuse Box
The fuse box in the passenger compartment is located under the glove compartment. To access the fuses:
- Remove the upholstery covering the fuse box by first pressing in the center pins in the mounting clips approximately 0.5 in (1 cm) with a small screwdriver and then pulling the pins out.
- Turn both retaining screws (2) counterclockwise until they release.
- Fold down the fuse box (3) half way. Pull it toward the seat until it stops. Fold it down completely. The fuse box can be unhooked completely.
- Replace the blown fuse.
- Close the fuse box in reverse order.
- Pull the center pins fully out of the mounting clips, secure the upholstery with the mounting clips and press the pins into the mounting clips again. The mounting clips then expand, holding the upholstery in position.
| No. | A | Protected Component |
|---|---|---|
| 37 | - | - |
| 38 | - | - |
| 39 | - | - |
| 40 | - | - |
| 41 | - | - |
| 42 | - | - |
| 43 | 15 | Integrated Audio Module (IAM - '06-'13), RTI Display, Phone Module (PHM), Multimedia Module (MMM), Accessory USB Unit (AUU ('08-'13)), Cellular Phone Handsfree Control Module ('08), USB-Port ('08-'13), Bluetooth Phone Module (BPM ('09--'13)) |
| 44 | 10 | Supplemental Restraint System Module (SRS), Engine Control Module (ECM (5-Cylinder - '08-'13)) |
| 45 | 15 | Front 12V Outlet, Rear 12V Outlet |
| 46 | 5 | Lights Switch Unit, Driver Information Module (DIM), Front Left/Right Lamp Housing ('06-'13), Front Lamp Housing, Glove Compartment Lighting, Left/Right Courtesy Lighting, Alcolock ('08-'13) |
| 47 | 5 | Ceiling Light, Rear Reading Light, Right Vanity Mirror Lighting, Left Vanity Mirror Lighting (except C70), Remote Control Unit For Garage Door Opener ('09-'13) |
| 48 | 15 | Rear Window Wiper Relay, Windshield Washer Motor Relay, Rear Window Washer Motor Relay, Washer Pump, Rear Window Wiper Motor |
| 49 | 10 | Supplemental Restraint System Module (SRS), Occupant Weight Sensor (OWS (USA/CDN)) |
| 50 | - | - |
| 51 | 10 | '04-'05: Front Left/Right Beam Length Adjustment Lamp Housing, Left Gas Discharge Lamp Master Control Module, Right Gas Discharge Lamp Slave Control Module, PTC Element (Diesel) |
| 10 | '06-'07: Fuel Filter Preheater Relay, Parking Assistance Module (PAM), Left Gas Discharge Lamp (GDL) Module (Master), Right Gas Discharge Lamp (GDL) Module (Slave), PTC-Element, Front Left/Right Lamp Housing (Beam Length Adjustment) | |
| 10 | '08-'13: Fuel Filter Preheater Relay, Differential Electronic Module (DEM), PTC-Element | |
| 52 | 5 | Brake Control Module (BCM), Transmission Control Module (TCM - '06-'13) |
| 53 | 10 | Electrical Power Steering Module (EPS) |
| 54 | 10 | '04-'05: Transmission Control Module (TCM), Generator |
| 10 | Diesel ('06-'07): Transmission Control Module (TCM) | |
| 10 | 5-Cylinder Petrol ('06-'07): Engine Control Module (ECM) | |
| 10 | '08-'13: Engine Control Module (ECM (5-Cylinder)), Parking Assistance Module (PAM), Left Gas Discharge Lamp (GDL) Module (Master), Right Gas Discharge Lamp (GDL) Module (Slave), Headlamp Control Module (HCM), Front Left/Right Lamp Housing | |
| 55 | 20 | '05-'13: Keyless Vehicle Module (KVM) |
| 56 | 10 | Siren Control Module (SCM), Remote Keyless Entry (RKE ('08-'13)), Remote Receiver Module (RRX ('08-'13)) |
| 57 | 15 | '04-'05: Engine Control Module (ECM), Central Electronic Module (CEM), Data Link Connector |
| 15 | '06-'13: Contact Brake Light, Data Link Connector | |
| 58 | 7.5 | '04 (L.E.): Auxiliary Light (Accessory) Relay, Right Gas Discharge Lamp Slave Control Module, Right High Beam |
| 10 | '04 (E.E.): Auxiliary Light (Accessory) Relay, Right Gas Discharge Lamp Slave Control Module, Right High Beam | |
| 7.5 | '05: Auxiliary Light (Accessory) Relay, Right Gas Discharge Lamp Slave Control Module, Right High Beam | |
| 7.5 | '06-'13: Auxiliary Light (Accessory) Relay, Right Gas Discharge Lamp (GDL) Module (Slave), Front Right Lamp Housing | |
| 59 | 7.5 | '04 (L.E.): Left Gas Discharge Lamp (GDL) Module (Master), Front Left Lamp Housing |
| 10 | '04 (E.E.): Left Gas Discharge Lamp (GDL) Module (Master), Front Left Lamp Housing | |
| 7.5 | '05: Auxiliary Light (Accessory) Relay, Right Gas Discharge Lamp (GDL) Module (Slave), Front Right Lamp Housing | |
| 7.5 | '06-'13: Left Gas Discharge Lamp (GDL) Module (Master), Front Left Lamp Housing | |
| 60 | 15 | Seat Heating Module (SHM) - Driver’s Side |
| 61 | 15 | Seat Heating Module (SHM) - Passenger Side |
| 62 | 20 | Sunroof Control Module |
| 63 | 20 | S40, V50: Right Rear Door Module (RDM) |
| 64 | 5 | Traffic Message Channel Module (TMC ('04-'07)), Global Positioning System Module (GPS ('04-'07)), Remote Digital Audio Receiver (RDAR - '06-'13), AM/FM Tuner Module (AFM - '04-'06) |
| 5 | C70: Left/Right Door Lock Indicator, Remote Digital Audio Receiver (RDAR), Traffic Message Channel Module (TMC ('06-'07)), Global Positioning System Module (GPS ('06-'07)) | |
| 65 | 5 | Remote Control IR Sensor, RTI Display, Audio Module (AUD), Left Amplifier Window Antenna (C30), Subwoofer Control Module Relay ('08-'11), Cellular Phone Handsfree Control Module ('04, '08), Right Rear Fender AM/FM Antenna and Amplifier (C70), Media Player Module (MPM - '04-'05), Multimedia Module (MMM - '04) |
| 66 | 10 | Climate Control Module (CCM), Integrated Audio Module (IAM - '06-'13), Infotainment Control Module (ICM) |
| 67 | 15 | '04: Subwoofer Module (SUB) |
| 68 | 5 | Steering Wheel Module (SWM) |
| 69 | 5 | Damper Motor Module (DMM) (Recirculation, Left-Hand Side, Right-Hand Side, Defroster, Floor/Ventilation), Rain Sensor Module (RSM), Air Quality Sensor (AQS), Climate Control Module (CCM ('08-'13)), Switch BLIS/PAS/DRIVe ('08-'13), Center Rear Belt Buckle Contact, Sunroof Control Module ('04-'05), Auto-Dimming Rearview Mirror ('04-'05), Ceiling Light ('04-'05) |
| 70 | - | - |
| 71 | - | - |
| 72 | - | - |
| 73 | 5 | Ceiling Light Switch Unit, Rear Left/Right Belt Buckle Contact, Sunroof Control Module, Auto-Dimming Rearview Mirror, Ceiling Light |
| 74 | 15 | Fuel Pump, Fuel Pump Control Module (Petrol), Additive Dosing Module (ADM ('09-'12)) |
| 75 | - | - |
| 76 | - | - |
| 77 | 15 | Accessory Electronic Module (AEM), Cargo Compartment 12V Outlet, Tow Hitch Cable Harness - 13-pin Outlet |
| 78 | - | - |
| 79 | 5 | Left/Right Reversing Light, Auto-Dimming Rearview Mirror |
| 80 | - | - |
| 81 | 20 | S40, V50: Rear Left Door Module (LDM) |
| 82 | 25 | Passenger Door Module (PDM) |
| 83 | 25 | Driver Door Module (DDM) |
| 84 | 25 | Power Seat Module (PSM), Power Passenger Seat Switch Unit |
| 85 | 25 | Power Seat Module (PSM), Power Driver’s Seat Switch Unit |
| 86 | 5 | Fuel Tank - DC/AC Converter ('06-'13), Power Seat Module (PSM), Cargo Compartment Lighting, Power Driver’s Seat Switch Unit, Power Passenger Seat Switch Unit, Load Assistance Switch ('08-'13), Left Vanity Mirror Lighting (C70) |
| 87 | - | - |
| 88 | - | - |
| 89 | - | - |
| 90 | - | - |
| 91 | - | - |
| 92 | - | - |
| Relay | ||
| R15 | Fuel Pump | |
| R18 | Comfort | |
| R1 | Interior Lighting | |
| R2 | Reversing Light | |
| R7A | Windshield Washer Motor | |
| R7B | Rear Window Washer Motor | |
| R8 | High Beam | |
| R11A | Rear Window Wiper | |
| R11B | Infotainment | |
Passenger Compartment Fuse Holder
| No. | A | Protected Component |
|---|---|---|
| 1 | 5 | Alcolock |
| 2 | 5 | Alcolock |
Engine Compartment Fuse Box
- Fuse Box
| No. | A | Protected Component |
|---|---|---|
| 1 | 50 | Cooling Fan Control Modul |
| 2 | 80 | Electrical Power Steering Module (EPS) |
| 3 | 60 | Сomfort Relay (R18), Central Electronic Module (CEM), Fuse No.: 45, 48, 49, 60, 61, 62, 63, 68, 69, 80 (08-), 84, 85 |
| 4 | 60 | High Beam Relay, Reverse Interlock Solenoid (Manual Transmission - '04), Central Electronic Module (CEM), Fuse No.: 55, 58, 59, 74, 77 |
| 5 | 80 | PTC Element |
| 6 | 60 | Diesel ('04-'05): Glow Plug Control Module |
| 60 | Diesel 4-Cylinder: Glow Plug | |
| 70 | Diesel 5-Cylinder: Glow Plug Control Module | |
| 7 | 30 | '06-'12: Brake Control Module (BCM) (Pump) |
| 40 | '13: Brake Control Module (BCM) (Pump) | |
| 8 | 20 | Brake Control Module (BCM) (Valves) |
| 9 | 30 | Main Relay (Engine Management System), Fuse No.: 32, 33, 34, 35, 36 |
| 10 | 40 | Fan Control Module |
| 11 | 20 | C30, S40, V50: Headlight Washer Motor Relay, High Pressure Headlight Washer Pump |
| 20 | С70: Convertible Roof Module (CRM), Headlight Washer Motor Relay, High Pressure Headlight Washer Pump | |
| 12 | 30 | Heated Rear Window Relay, Heated Rear Window |
| 13 | 30 | Starter Motor |
| 14 | 40 | Trailer Module (TRM), 13-pin Outlet (Tow Hitch Cable Harnes) |
| 15 | 30 | С70: Convertible Roof Module (CRM) |
| 16 | 30 | C30, S40, V50: Infotainment Relay, Audio Module (AUD), Fuse No.: 22, 43, 64, 65, 66, 67 |
| 40 | С70: Infotainment Relay, Audio Module (AUD), Fuse No.: 22, 43, 64, 65, 66, 67 | |
| 17 | 30 | Wiper Motor Module (WMM) |
| 18 | 40 | Reversing Light Relay, Interior Lighting Relay, Central Electronic Module (CEM), Fuse No.: 46, 47, 56, 57, 79, 81, 82, 83, 86 |
| 19 | - | - |
| 20 | 15 | Horn Relay, Horn 1 & 2 |
| 21 | 20 | Combustion Preheater Module (CPM) |
| 22 | 15 | '05: Subwoofer Module (SUB) |
| 25 | '06-'11: Subwoofer Module (SUB) | |
| 20 | '11-'13: Subwoofer Module (SUB) | |
| 25 | С70: Subwoofer Module (SUB) | |
| 23 | 10 | Transmission Control Module (TCM), Engine Control Module (ECM (5-Cylinder)) |
| 15 | 6-speed PowerShift - MPS6 ('09-'13): Transmission Control Module (TCM) | |
| 24 | 20 | Diesel: PTC-Resistor - Crankcase Ventilation (5-Cylinder - '06-'13), Electrically Heated Fuel Filter |
| 25 | 10 | '10-: Secondary Battery (1.6l Diesel), Central Electronic Module (CEM (1.6l Diesel)) |
| 26 | 15 | Starter Motor Relay, Start Control Module (SCU), Engine Control Module ('04-'05), Central Electronic Module (CEM), Fuse No.: 44, 51, 52, 53, 54, 73 and Fuse in Holder |
| 27 | 10 | Electromagnetic Clutch (Climate Control System) |
| 28 | 10 | '05: Climate Control Module (CCM), Multimedia Module (MMM) |
| 29 | 15 | Front Fog Lights Relay, Front Left/Right Fog Light |
| 30 | 3 | Diesel 4-Cylinder: Engine control module (ECM (2.0l Diesel, 1.6l Petrol)) |
| 10 | '10-'13: Coolant Pump (1.6l Diesel) | |
| 31 | 10 | '04-'05 (Diesel): Alternator (Voltage Regulator) |
| 10 | '06-'13 (4-Cylinder): Alternator (Voltage Regulator) | |
| 32 | 10 | Petrol ('04): Injectors |
| 10 | '05: Fuel Filter Pre-Heater Relay, Front Heated Oxygen Sensor, Injectors (Petrol), Valve Coolant | |
| 10 | '06-'13: Mass Airflow Sensor (MAF) (5-Cylinder Diesel), Regulator Motor (Turbo), Front Heated Oxygen Sensor (4-Cylinder), Rear Heated Oxygen Sensor (4-Cylinder), Injection Valves (5-Cylinder), Coolant Valve (4-Cylinder 2.0L Diesel), Rear Heated Oxygen Sensor (4-Cylinder 1.6L Diesel ('07)), Glow Plug System Relay ('08-'13), Intercooler Bypass Valve (1.6l Diesel), Fuel Flow Control Valve ('11) | |
| 33 | 20 | '04: Fuel Filter Pre-Heater Relay (Diesel), Vacuum Pump, Front/Rear Heated Oxygen Sensor |
| 20 | '05: Vacuum Pump, Front/Rear/Middle Heated Oxygen Sensor | |
| 20 | '06-'13: Vacuum Pump Switch, Engine Control Module (ECM (5-Cylinder Diesel)), Vacuum Pump (5-Cylinder), Front Heated Oxygen Sensor (5-Cylinder), Rear Heated Oxygen Sensor (5-Cylinder), Center Heated Oxygen Sensor (5-Cylinder without Turbo), PTC-Resistor - Crankcase Ventilation (4-Cylinder 2.0L), Heated Fuel Filter (Diesel), Vacuum Pump Relay ('10-'13) | |
| 34 | 10 | '04: Engine Control Module (ECM), Fuel Volume Control Valve (Diesel), Fuel Pressure Control Valve (Diesel), Spark Plug and Ignition Coil |
| 10 | '05: Engine Control Module (ECM - 5-Cylinder), Injection Valves, Injector, Fuel Volume Control Valve (Diesel), Spark Plug and Ignition Coil, Transformer - Ignition Coils, PTC Resistor - Oil Trap | |
| 10 | '06-'13: EGR Valve, Fuel Pressure Control Valve ('06-'07), Spark Plug and Ignition Coil, EGR Cooling Bypass Valve ('06-'08), Fuel Pressure Bypass Valve (Man), Injection Valves (1.6l), Fuel Volume Control Valve (4-Cylinder 2.0l Diesel), Fuel Flow Control Valve (4-Cylinder 1.6l Diesel), Pressure Monitor (Climate Control System (5-Cylinder)), Ignition Coils (Transformer (1.6l)), Glow Plug Control Module (GCU (5-Cylinder Diesel - '08-)), EGR Valve (5-Cylinder Diesel - '08-'13), Starter Motor Relay (1.6l Diesel - '10-'13), Battery Relay (1.6l Diesel - '10-'13), Secondary Battery Relay (1.6l Diesel - '10-'13), Coolant Pump Relay (1.6l Diesel - '10-'13), Engine Control Module (1.6l Diesel - '10-'13), Front Heated Oxygen Sensor (4-Cylinder - '11-'13) | |
| 35 | 10 | '04 (E.E.): Climate Control System Relay, Fuel Leakage Control Pump, Mass Airflow Sensor (MAF), EVAP Valve, Intake Variable Valve Timing Solenoid, Turbocharger Control Valve, Variable Valve Timing Outlet Solenoid, Bypass Valve (Diesel), Variable Turbo Geometry Solenoid (Diesel), Expansion Tank Cut-off Valve (Diesel), Intake Control Valve (Diesel), PTC Resistor - Oil Trap |
| 15 | '04 (L.E.): Climate Control System Relay, Fuel Leakage Control Pump, Mass Airflow Sensor (MAF), EVAP Valve, Intake Variable Valve Timing Solenoid, Turbocharger Control Valve, Variable Valve Timing Outlet Solenoid, Bypass Valve (Diesel), Variable Turbo Geometry Solenoid (Diesel), Expansion Tank Cut-off Valve (Diesel), Intake Control Valve (Diesel), PTC Resistor - Oil Trap | |
| 15 | '05: Climate Control System Relay, Fuel Leakage Control Pump, Engine EGR, Mass Airflow Sensor (MAF), Water Detection Sensor, Injection Valves, EVAP Valve, Intake Variable Valve Timing Solenoid, Turbocharger Control Valve, Power Steering Pressure Switch, Variable Valve Timing Outlet Solenoid, Bypass Valve (Diesel), Variable Turbo Geometry Solenoid (Diesel), Intake Valve Mixing Air/Fuel Control Valve (Diesel), PTC-Resistor Air Preheating | |
| 15 | '06-'07: Climate Control System Relay, Fuel Leakage Control Pump, Engine EGR (1.6l Diesel - '06-'11), Mass Airflow Sensor (MAF), Water Detection Sensor, Injection Valves, EVAP Valve, Intake Variable Valve Timing Solenoid, Turbocharger Control Valve, Power Steering Pressure Monitor, Variable Valve Timing Outlet Solenoid, Control Valve Inlet, Variable Turbo Geometry Solenoid (4-Cylinder Diesel), Valve Mixing Air/Fuel (5-Cylinder 1.8l & 2.0l), Engine Control Module (5-Cylinder Diesel), Crankcase Ventilation PTC-Resistor (5-Cylinder Petrol) | |
| 15 | '08-'13: Climate Control System Relay, Engine Control Module (5-Cylinder Diesel), Fuel Leakage Control Pump (5-Cylinder), EGR Motor (1.6l Diesel, 1.8l Petrol), Mass Air Flow Sensor (MAF (5-Cylinder Petrol, 4-Cylinder Diesel)), Water Detection Sensor (4-Cylinder Diesel), Injection Valves (1.8l), EVAP Valve (Petrol), Intake Variable Valve Timing Solenoid (5-Cylinder Petrol), Turbocharger Control Valve (2.5l Turbo), Variable Intake Manifold Vacuum Valve (1.8l), Power Steering Pressure Switch (1.6l), Fuel Volume Control Valve (2.0l Diesel - '08-'10), Exhaust Variable Valve Timing Solenoid (2.5l Turbo), Variable Turbo Geometry Solenoid (4-Cylinder Diesel), Air/Fuel Mixing Valve (1.8l), Intake Control Valve (2.0l Diesel), PTC-resistor - Crankcase Ventilation (5-Cylinder Petrol), EGR Cooling Bypass Valve ('11-'13) | |
| 36 | 10 | Engine Control Module (ECM), Front Heated Oxygen Sensor (5-Cylinder Diesel - '06-'13), Accelerator Pedal Sensor |
| Fuse in Holder | ||
| * | 20 | Front Left/Right Auxiliary Lights |
| Relay | ||
| R1 | '10-'13: Coolant Pump | |
| R2 | Horn | |
| R3 | '10-'13: Vacuum Pump | |
| R4 | Front Fog Light | |
| R5 | Fuel Filter Preheate | |
| R6 | '10-'13: Autostart | |
| R7 | '10-'13: Secondary Battery | |
| R8 | - | |
| R9 | Headlight Washer Motor | |
| R10 | Heated Rear Window | |
| R11 | Climate Control System | |
| R12 | Diesel ('08-'13): Glow Plug System | |
| R13 | Starter Motor | |
| R14 | Main (Engine Management System) | |
Fusible Link
| No. | A | Protected Component |
|---|---|---|
| 1 | 150 | Starter Motor, Alternator |
| 2 | 150 | Engine Compartment Fuse Box |
Main Fuse Box Battery ('10-'13)
| No. | A | Protected Component |
|---|---|---|
| 1 | 125 | Alternator, Engine Compartment Fuse Box |
| 2 | 15 | Battery Monitoring Sensor (BMS) |
Engine Compartment Fuse Holder ('10-'13)
| A | Protected Component |
|---|---|
| 70 | Cable Fuse by Secondary Battery |
| 70 | Cable Fuse in Engine Compartment Fuse Box |
Battery Relay ('10-'13)
Auxiliary Light Relay
