2001-2009 Volvo S60 and S60 R
Location
- Engine compartment fuse box (2001-2005) / (2006-2009)
- Fuse box in the passenger compartment within the sound barrier on the driver’s side (2005-2009)
- Fuse box in the passenger compartment at dashboard end on driver’s side
- Fuse box in cargo compartment (2001-2004) / (2005-2009)
Engine compartment fuse box (2001-2005)
| No. | A | Description |
|---|---|---|
| 1 | 25 | Parking heater (option) |
| 2 | 20 | Auxiliary lamps (option) |
| 3 | 10 | 2005: Throttle (5-cyl without turbo/Bi-fuel) |
| 4 | 20 | Petrol: Oxygen sensors 2004-2005; Diesel: Engine Control Module (ECM), high-pressure valve |
| 5 | 15 | 2001-2002: Crankcase ventilation heater, solenoid valves |
| 10 | 2003-2005: Crankcase ventilation heater, Solenoid valves 2004-2005; Bi-Fuel: Fuel distributor | |
| 6 | 15 | Petrol: Mass an flow sensor, engine control modulo, injectors |
| 10 | Diesel: Mass air flow sensor | |
| 7 | 10 | 2001-2004: Throttle control |
| 8 | 10 | Accelerator pedal sensor (APM), A/C compressor, fan electronics box (2003-2005) |
| 9 | 15 | 2001-2004: Horn |
| 10 | 2005; Bi-fuel LPG: Gas tank valve | |
| 10 | - | - |
| 11 | 20 | 2001-2004: A/C compressor, Ignition coils, Electric fan (2001-2002), Solenoid valves (2004; diesel) 2005: Ignition coils, relay coils |
| 12 | 5 | 2001-2004: Brake light contact |
| 13 | 25 | Windscreen wipers |
| 14 | 30 | ABS / STC (203-2004) / DSTC (2001-2004) |
| 15 | 15 | 2004; Bi-Fuel: Gas tank valve (Bi-Fuel |
| 35 | 2005: High-pressure washer, headlamps | |
| 16 | 15 | 2001-2004: Windshield wipers, headlight washers |
| 17 | 10 | 2002-2004: Dipped beam (right) |
| 20 | 2005: Dipped beam (right) | |
| 18 | 10 | 2002-2004: Dipped beam (right) |
| 15 | 2005: Parking lamps (front) | |
| 19 | 30 | ABS / STC (203-2004) / DSTC (2001-2004) |
| 20 | 15 | 2002-2004: Main beam (left) |
| 20 | 2005: Dipped beam (right) | |
| 21 | 15 | 2002-2004: Main beam (right) |
| 15 | 2005: Fuel pump | |
| 22 | 25 | 2001-2003: Starter motor |
| 40 | 2004: Starter motor | |
| 35 | 2005: Starter motor | |
| 23 | 5 | 2001-2004: Engine Control Module (ECM) |
| 10 | 2005: Engine Control Module (ECM) supply, engine relay (ECR) coil | |
| 24 | - | Not used |
Engine compartment fuse box (2006-2009)
| No. | A | Description |
|---|---|---|
| 1 | 30 | ABS |
| 2 | 30 | ABS |
| 3 | 35 | High-pressure washer, headlamps |
| 4 | 25 | Parking heater |
| 5 | 20 | Auxiliary lamps |
| 6 | 35 | Starter motor relay |
| 7 | 25 | Windscreen wipers |
| 8 | 15 | 2006-2007: Transmission control module (TCM), diesel, R-models |
| 15 | 2008-2009: Fuel pump | |
| 9 | 15 | 2006-2007: Fuel pump |
| 15 | 2008-2009: Transmission control module (TCM), diesel | |
| 10 | 20 | Ignition coils (petrol), engine control module (ECM), injection valves (diesel) |
| 11 | 10 | Accelerator pedal sensor (APM), AC compressor, fan electronics box |
| 12 | 15 | Petrol: Engine control module (ECM), injection valves, mass air flow sensor |
| 5 | Diesel: Mass air flow sensor | |
| 13 | 10 | Petrol: Electronic throttle module (ETM) |
| 15 | Diesel: Electronic throttle module (ETM), air mixing valve, fuel pressure regulator, solenoid valve | |
| 14 | 20 | Petrol: Lambda-sond |
| 10 | Diesel: Lambda-sond | |
| 15 | 10 | Petrol: Crankcase ventilation heater, solenoid valves |
| 15 | Diesel: Solenoid valves, glow plugs | |
| 16 | 20 | Dipped beam, left |
| 17 | 20 | Dipped beam, right |
| 18 | - | - |
| 19 | 5 | Engine control module (ECM) supply, engine relay |
| 20 | 15 | Position lamps |
| 21 | 20 | 2009: Vacuum pump |
Fuses in the passenger compartment
| No. | A | Description |
|---|---|---|
| 1 | 10 | 2001-2002: Left low beam |
| 15 | 2003-2004: Headlamps (dipped beam), Bi-Xenon (option) | |
| 25 | 2005-2009: Power driver’s seat | |
| 2 | 10 | 2001-2002: Right low beam |
| 20 | 2003-2004: Headlamps (main beam) | |
| 25 | 2005-2009: Power passenger seat | |
| 3 | 15 | 2001-2002: Headlights, low beams |
| 30 | 2003-2004: Power driver's seat 2005-2009: Climate control system fan | |
| 4 | 20 | 2001-2002: Headlights, high beams |
| 30 | 2003-2004: Power passenger seat | |
| 25 | 2005-2009: Control module, right front door | |
| 5 | 30 | 2001-2002: Power driver's seat |
| 15 | 2003-2004: Speed-dependent power steering, vacuum pump | |
| 25 | 2005-2009: Control module, left front door | |
| 6 | 30 | 2001-2002: Power passenger seat |
| 5 | 2004; Bi-Fuel: Gas tank valve | |
| 10 | 2005-2009: General lighting, ceiling (RCM), Upper Electronic Module (UEM) | |
| 7 | 15 | 2001-2004: Heated seat (front left) 2005-2009: Sunroof |
| 8 | 15 | 2001-2004: Heated seat (front right) |
| 7,5 | 2005-2009: Ignition switch, SRS system, Engine Control Module (ECM), SRS deactivation passenger side (PACOS), immobiliser (IMMO), Transmission control module (TCM; Diesel and R-models - from 2006) | |
| 9 | 5 | 2001-2004: ABS / STC (2003-2004) / DSTC (2003-2004) 2005-2009: OBDII, light switch (LSM), Steering Angle Sensor (SAS), Steering Wheel Module (SWM) |
| 10 | 15 | 2001-2002: Left high beam |
| 20 | 2005-2009: Audio | |
| 11 | 15 | 2001-2002: Right high beam |
| 30 | 2005-2009: Amplifier | |
| 12 | 15 | 2001-2004: Headlamp levelling (2004), headlamp wipers |
| 10 | 2005-2009: RTI display | |
| 13 | 20 | 2001-2002: Electric socket 12V |
| 15 | 2003-2004: Electric socket 12V | |
| 5 | 2005-2009: Telephone | |
| 14-38 - 2005-2009: Not used | ||
| 14 | 5 | Power seat passenger side, Front seat belt buckle (2001-2002) |
| 15 | 5 | 2001-2003: Audio, VNS 2004: Audio RTI (option) |
| 16 | 20 | Audio |
| 17 | 30 | Amplifier |
| 18 | 5 | 2001-2002: Front fog lights |
| 15 | 2003-2004: Front fog lights | |
| 19 | 10 | 2001-2003: VNS 2004: RTI-display (option) |
| 20 | 5 | 2002: Transport switch |
| 21 | 10 | Automatic transmission, shiftlock, extended D2 feed |
| 22 | 20 | Direction indicators |
| 23 | 5 | Light switch module, Switch module (2001-2002), Climate and comfort functions, Diagnostic connector, Steering wheel module |
| 24 | 10 | 2001-2002: Relay increase X- feed: Climate control, Power driver's seat, Driver info 2003-2004: Extended Dl-feed, climate control system, power seat (driver), combined instrument panel, parking heater (option) |
| 25 | 10 | 2001-2002: Ignition switch 30 feed: Central electronic module: 50, S, X, 15 Airbag X, Relay X, Relay 15, Relay Starter motor 2003: Ignition switch, relay starter motor, SRS, engine control module 2004: Ignition switch (30-feed), Central Electronic Module, relay starter motor, engine control module |
| 26 | 30 | Climate control system blower |
| 27 | 15 | 2001-2002: Electronic module - front doors and door mirrors 2004: Active chassis FOUR-C |
| 28 | 10 | Electronic module (roof), interior lighting (ceiling) |
| 29 | 10 | Telephone |
| 30 | 10 | 2001-2002: Position/parking lamps (left - front and rear) |
| 7,5 | 2003-2004: Position/parking lamps (left - front and rear) | |
| 31 | 10 | 2001-2002: Position/parking lamps (right - front and rear), numberplate lighting |
| 7,5 | 2003-2004: Position/parking lamps (right - front and rear), numberplate lighting | |
| 32 | 10 | Central electrical module, vanity mirror lighting, power steering, glove compartment light (2003-2004), interior courtesy lighting (2003) |
| 33 | 15 | Fuel pump |
| 34 | 15 | Sunroof |
| 35 | 25 | Central locking system, power windows. left door mirror |
| 36 | 25 | Central locking system, power windows. right door mirror |
| 37 | 30 | Rear power windows, power child safety locks (2003-2004) |
| 38 | 5 | 2003-2004: Alarm siren |
Fuses in the passenger compartment within the sound barrier on the driver’s side (2005-2009)
| No. | A | Description |
|---|---|---|
| 1 | 15 | Seat heating, right side |
| 2 | 15 | Seat heating, left side |
| 3 | 15 | Horn |
| 4 | - | - |
| 5 | - | - |
| 6 | - | Reserve |
| 7 | - | Reserve |
| 8 | 5 | Siren |
| 9 | 5 | Brake lamp switch feed |
| 10 | 10 | Combined instrument panel (DIM), climate control (CCM) parking heater, power driver's seat |
| 11 | 15 | Front and rear seat socket |
| 12 | - | - |
| 13 | - | Reserve |
| 14 | 15 | S60 R, 2005-2006: Headlamp wipers |
| 15 | 5 | ABS, STC/DSTC |
| 16 | 10 | Bi-fuel, Electronically Controlled Power Steering (ECPS), Bi-Xenon, headlamp levelling |
| 17 | 7,5 | Fog lamp, front left |
| 18 | 7,5 | Fog lamp, front right |
| 19 | - | Reserve |
| 20 | - | Reserve |
| 21 | 10 | Transmission Control Module (TCM), reverse gear inhibitor (M66) |
| 22 | 10 | Main beam, left |
| 23 | 10 | Main beam, right |
| 24 | - | - |
| 25 | - | - |
| 26 | - | Reserve |
| 27 | - | Reserve |
| 28 | 5 | Power passenger seat, audio |
| 29 | 7,5 | 2008-2009: BiFuel, fuel pump |
| 30 | 5 | BLIS |
| 31 | - | Reserve |
| 32 | - | Reserve |
| 33 | 20 | Vacuum pump |
| 34 | 15 | S60 R, 2005-2006: Washer pump, headlamp wipers |
| 35 | - | - |
| 36 | - | - |
Fuses in the cargo compartment (2001-2004)
| No. | A | Description |
|---|---|---|
| 1 | 10 | Rear electronic module, Cargo compartment lighting |
| 2 | 10 | Rear fog lamps |
| 3 | 15 | Brake light |
| 4 | 10 | Backup lights |
| 5 | 5 | Rear window defroster, Relay 15I (accessories) |
| 6 | 10 | Tailgate opening |
| 7 | 10 | Folding head restraints |
| 8 | 15 | Central locking rear doors, Fuel filler door |
| 9 | 15 | Trailer hitch (30 feed) (accessory) |
| 10 | 10 | CD changer, CD ROM (2001-2002), VNA (2001-2002), Antenna (2001-2002), VNS (2003), RTI (2004) |
| 11 | 15 | Accessory control module (AEM) |
| 12 | - | - |
| 13 | - | - |
| 14 | 7,5 | 2003-2004: Brake light |
| 15 | 20 | Trailer hitch (15 I feed) |
| 16 | 15 | Electric socket, cargo compartment (option) |
| 17 | 7,5 | Diesel, 2004: Heated fuel filter AWD cars, 2002-2004:Control module, all-wheel drive |
| 18 | 15 | Diesel, 2004: Heated fuel filter |
Fuses in the cargo compartment (2005-2009)
| No. | A | Description |
|---|---|---|
| 1 | 10 | Reversing lamp |
| 2 | 15 | 2005-2007: Parking lamps, fog lamps, cargo compartment lighting, number plate lighting, LEDs in brake lighting |
| 20 | 2008-2009: Position lamps, fog lamps, cargo area lighting, number plate lighting, lamps in brake lighting | |
| 3 | 20 | 2005-2007: Accessories (AEM) |
| 15 | 2008-2009: Accessories (AEM) | |
| 4 | - | Reserve |
| 5 | 10 | REM electronics |
| 6 | 7,5 | CD changer, TV, RTI |
| 7 | 15 | Towing bracket wiring (30-feed) |
| 8 | 15 | Cargo compartment socket |
| 9 | 20 | Rear right door: power window, power window lock |
| 10 | 20 | Real left door: power window, power window lock |
| 11 | - | Reserve |
| 12 | - | Reserve |
| 13 | 15 | Diesel filter heater |
| 14 | - | - |
| 15 | - | Reserve |
| 16 | - | Reserve |
| 17 | 5 | Audio accessories |
| 18 | - | Reserve |
| 19 | 15 | Foldable head restraint |
| 20 | 20 | Towing bracket wiring (15-feed) |
| 21 | - | Reserve |
| 22 | - | - |
| 23 | 7,5 | AWD |
| 24 | 15 | Four-C SUM |
| 25 | - | - |
| 26 | 5 | Parking assistance |
| 27 | 30 | Main fuse: Towing bracket wiring, Four-C, Parking assistance, AWD |
| 28 | 15 | Central locking system (PCL) |
| 29 | 25 | Trailer lighting, left: parking lamp, direction indicator |
| 30 | 25 | Trailer lighting, right: brake lamp, rear fog lamp, direction indicator |
| 31 | 40 | Main fuse: Fuse 37, 38 |
| 32 | - | - |
| 33 | - | - |
| 34 | - | - |
| 35 | - | - |
| 36 | - | - |
| 37 | 20 | Heated rear window |
| 38 | 20 | Heated rear window |